Permanent fix for the spline issue is in!

So, got my Active E on Friday and didn’t really put any miles on it this weekend.

We had our annual holiday party with our friends at our house, so, didn’t really do much driving. I did let a couple of friends test drive the car to get them ready to EVolve into the EV lifestyle. Consistent with the theme of my blog, we discussed this as PURELY an economic decision on top of the PERFORMANCE of a BMW Electric vehicle and it’s scheduled successors in the BMWi family.

Glad to say that it looks like it’s performing as it did prior to the week long service in the shop. Apparently a new technician worked on my vehicle this past week and I have to say that I can tell. The original technician was very meticulous and the vehicle felt restored to me as before. However upon inspection of my vehicle this weekend, I noticed a spare plastic piece that seems to be lose and I can’t figure out where it came from. Additionally the carpet covered pieces in the trunk don’t seem to be flush against each other as opposed to how my original technician delivers the vehicle to me.

I have not had time to check launch control. However, I did notice that I finished my commute to work about 3-4% state of charge LESS than I normally do. The weather is a nice Southern California 65-70 today, HOWEVER, a lot of people seem to be off as I was going closer to 75-80 on parts of my commute that would normally be slower (have to keep up with the rest of traffic.) So, that’s probably it.

So, what was the permanent fix? Basically a plug that fits in the E-motor to keep the lubricant back to the junction between the motor and the gears so that it does not get spun off by the torque of the motor. I don’t have a picture, but should I run across one, I’d make sure to post.

Published by

Dennis

rEVolutionary armed with a Tesla Model S S85 and a Tesla Roadster, when his wife let's him borrow it. Formerly driving a BMW Active E (2012-Feb to 2014-Feb). Dennis has been driving EVs since he found himself on the BMW Active E trials on February 2012. As a result of his involvement in the Active E program, he became Accidentally Environmental. Aside from this blog, he often tweets @dennis_p. When not driving, he can be found on the following Tesla/EV forums - teslamotorsclub.com, teslamotors.com, and model3ownersclub.com as AEdennis or on speakev.com as Dennis. In the interest of full disclosure, Dennis has an inherent bias toward electric vehicles and has an investment in and is LONG Tesla (NASDAQ: TSLA).

Leave a Reply

This site uses Akismet to reduce spam. Learn how your comment data is processed.